簡易檢索 / 詳目顯示

研究生: 黃信植
Hsing-chih Huang
論文名稱: 太陽能電池導電銀膠對銀-矽界面結構與電池效率之影響 台灣科技大學
Effects of Solar Conductive silver paste on Ag-Si interface and Solar cell efficiency
指導教授: 林舜天
Shun-Tian Lin
口試委員: 周賢鎧
Shyan-kay Jou
林寬泓
Kuan-Hong Lin
郭昭輝
Chao-Hui Kuo
學位類別: 碩士
Master
系所名稱: 工程學院 - 機械工程系
Department of Mechanical Engineering
論文出版年: 2012
畢業學年度: 100
語文別: 中文
論文頁數: 75
中文關鍵詞: 太陽能電池導電銀膠銀-矽介面再結晶銀
外文關鍵詞: Solar cell, Conductive silver paste, Ag-Si interface, recrystallization silver
相關次數: 點閱:237下載:10
分享至:
查詢本校圖書館目錄 查詢臺灣博碩士論文知識加值系統 勘誤回報
  • 為了提升太陽能電池效率,正面電極的改良一直是研究的重點,而如何有效的減少電極電阻,又不影響其結構強度,從電極和矽晶圓之間的微結構,再結晶銀的尺寸和數量對電性的影響可一窺端倪。為此,本研究藉著改變溫度、添加劑種類、金屬粉末比例,玻璃粉末比例,研究其微結構,且歸納出最佳的導電銀膠比例,最後實際測試電性做以應證。以SEM觀察微結構變化,實驗結果顯示,隨著溫度的上升,表面電極燒結致密度和銀-矽介面的再結晶銀尺寸會跟著向上提升,但含添加劑的試片,在較低溫度就能有相同的效果。玻璃粉末的增加,也會使再結晶銀的尺寸和數量上升,但當其比例過高時,除表面電極的空孔會增加,影響電極本身結構強度外,更會直接使得Isc短路電流下降,降低效率。討論前面實驗之結果,最後降低了玻璃含量,增加金屬粉末填充率,並選擇最佳的添加劑,燒結並做IV測試,再調整背電極鋁膠種類與燒結設備的參數,初步的優化已得到電池效率17.14%之產品,但銀膠的成本約只有市售商品75-80%。


    In order to improve the efficiency of solar cells, the positive electrode

    of improvement has been the focus of the study. How to reduce the

    electrode resistance effectively, without affecting its structural strength.

    Interface micro-structure between the eleode and the silicon wafer, and

    recrystallization of silver can gives some result. In this study, change

    temperature, types of additives, the proportion of metal powder and glass

    powder proportion than observed the micro-structure. Than mix the best

    proportion of conductive silver paste. Finally, test of the electrical

    properties by IV-tester. Observation SEM of the micro-structural, the

    experimental results show that the rises of temperature, the surface

    electrodes sintered density and silver - silicon interface recrystallization

    silver size will follow the increase, but add to some special additives

    have the same effect at lower temperatures. Increase of the glass powder,

    also make the size and number of crystalline silver rise, but when the

    ratio is too high, the hole will increase on the electrode surface than

    structural strength turns into low , and it makes Isc (short-circuit current)

    decline, reduce cell efficiency directly. Discuss the results of previous

    experiments that reduce the glass powder content, increasing the fill rate

    of metal powders, and select the best additives, sintering temperature than

    work the IV test. Next step adjust the back electrode aluminum plastic

    types and the parameters of the sintering equipment. After preliminary

    optimization, we got the cell efficiency of 17.14%, but the cost of the

    silver paste only about commercial products 75-80%

    摘要…………………………………………………………….…………I Abstract……………………………………………………..……………II 目錄…………………………………………………………….……..…V 誌謝……………………………………………………...……...………IV 圖目錄…………………………………………………………..….….VII 表目錄…………………………….……………………………..…..…XI 第一章 前言………………………………………….………………….1 1.1太陽能電池…………………………………………………1 1.2太陽能電池簡史……………………………………………2 第二章 基礎理論與文獻回顧……………………..……………………3 2.1光電效應與太陽能電池原理…………………………….…3 2.2太陽能電池製造原理與流程…………………...……….….5 2.2.1多晶矽太陽能電池製作流程………………..…………8 2.3太陽能電池用導電漿料………………...…………………20 2.3.1正電極用導電銀膠………………...………………….20 第三章 實驗流程………………………………...………………….…25 3.1.1銀粉選用………………………………………………25 3.1.2玻璃粉選用…………………...……………………….27 3.1.3有機載體選用…………………………….…………...28 3.1.4添加劑種類……………………………...…………….29 3.2實驗方法…………………………………..……………….30 3.3實驗設備……………………..…………………………….30 3.4實驗流程……………………..…………………………….32 第四章 結果與討論……………………….……………………….…..33 4.1溫度和界面活性劑對銀電極和矽晶圓界面之影響……..33 4.2銀粉添加量對銀電極和矽晶圓界面之影響……...………39 4.3玻璃添加量對銀電極和矽晶圓界面之影響…………...…42 4.4 電性結果……………………..……………….…………..51 第五章 結論………………...………………………………………….55 第六章 參考文獻……………………...………….……………………57

    1.工業研究院太電中心, http://www.itri.org.tw/chi/gel/

    2.A.R. Jha, “Solar cell technology and applications”

    3.P. Jayarama Reddy, Science & technology of photovoltaics

    4.李正裕, “The study on screen-printed Metallization of solar Cell”,國立台 灣科技大學,2008年

    5.黃厚穎, “Study of silicon-based solar cell” 國立台灣科技大學,2006年

    6.Winfried Hoffmann, Towards an Effective European Industrial Policy for PV Solar Electricity, EPIA June 2004年, Paris France, 19th EPVSECv

    7.Seong Je Jeon a,b, Sang Man Koo a, Seon Am Hwang b,“Optimization of lead-and cadmium-free front contact silver pasteFormulation to achieve high fill factors for industrial screen-printed Si solar cells”

    8.Mohamed M. Hilalia,z, Mowafak M. Al-Jassim b, Bobby To b, Helio Moutinho b,Ajeet Rohatgi a,*, and Sally Asher, “Understanding the Formation and Temperature Dependence of Thick-Film Ag Contacts on High-Sheet-Resistance Si Emitters for Solar Cells”

    9. R. Lago1*, L. Pe’ rez1, H. Kerp2, I. Freire1, I. Hoces1, N. Azkona1, F. Recart1 and J. C. Jimeno1 , “Screen printing metallization of boron emitters”

    10.S.B. Rane*, P.K. Khanna, T. Seth, G.J. Phatak, D.P. Amalnerkar, B.K. Das, “Firing and processing effects on microstructure of fritted silver thick film electrode materials for solar cells”

    11.D. Pysch*, A. Mette, A. Filipovic and S. W. Glunz, “Series Resistance Characterization of Industrial Silicon Solar Cells With Screen-printed Contacts Using Hotmelt Paste”

    12.D. Pysch*, A. Mette, A. Filipovic and S. W. Glunz, “Comprehensive Analysis of Advanced Solar Cell Contacts Consisting of Printed Fine-line Seed Layers Thickened by Silver Plating”

    13.Mitsunori Nakatani, Shoichi Karakida, Hiroaki Morikawa, Satosi Arimoto, “Investigation of rapid thermal firing for high efficiency of large area multi-crystalline Si solar cells”

    14.A. Ebonga,*, J. Brodya, A. Rohatga, T. Williamsb, “Optimization of front metal contact "ring scheme to achieve high "ll factors on screen printed silicon solar cells”

    15.Mohamed M. Hilali14, Srinivasan Sridhran2, Chandra Khadilkar2, Aziz Shaikh3, Ajeet Rohatg1, and Steve Kim3, “Effect of Glass Frit Chemistry on the Physical and Electrical Properties of Thick-Film Ag Contacts for Silicon Solar Cells”

    16.Kyoung-Kook Hong a, Sung-Bin Cho a, Jae Sung You b, Ji-Weon Jeong b, Seung-Mook Bea c, Joo-Youl Huh a, “Mechanism for the formation of Ag crystallites in the Ag thick-film contacts of crystalline Si solar cells”

    17.Dong Zhang, Jerone Moyer, Weiming Zhang, “Front contact pastes with increased aspect ratio to achieve higher efficiency on screen printed solar cells”

    18.Dongsun Kim, Seungbo Shim, Seongjin Hwang, and Hyungsun Kim “Electrical Properties of Screen Printed Silicon Solar Cell Dependent upon Thermophysical Behavior of Glass Frits in Ag Pastes”

    19.Mohamed M. Hilalia ,Kenta Nakayashiki a, Chandra Khadilkar b,Robert C. Reedy c, Ajeet Rohatgi a, Aziz Shaikh d, Steve Kim d, and Srinivasan Sridharanb, “Effect of Ag Particle Size in Thick-Film Ag Paste on the Electrical and Physical Properties of Screen Printed Contacts and Silicon Solar Cells”

    20. Sung-Bin Cho a, Kyoung-Kook Hong a, Joo-Youl Huha,*, Hyun Jung Park b, Ji-Weon Jeong b, “Role of the ambient oxygen on the silver thick-film contact formation for crystalline silicon solar cells”

    21.Sung-Bin cho1, Kyoung-Kook Huang1, Bo-Mook Chung1.2, and Joo-Youl Huh, “Influence of firing Ambience on fire-through Silver contact Metallization for crystalline silicon solar cells”

    22.P.N. Vinod, “Evaluation of the ohmic properties of the silver metal contacts of an improved sintering process on the multicrystalline silicon solar cells”

    23.M.hilali1, J.-W. Jeong1, A-Rohatgi1, D. L. Meier2, and A. F. Carroll3, “Optimization of Self Doping Ag Paste Firing to Achieve High Fill Factors on Screen-Printed Silicon solar cells with a 100Ω/sq. Emitter

    24.Jung Min Kim, Young Kwan Kim, ”Thin crystalline silicon solar cell bonded to sinteredsubstrate with aluminum paste”

    25.Quantitative comparison of simulated and experimental silver crystal formation at the interface of silver thick film contacts on n-type silicon Energy Procedia (January 2011), 8, Complete, pg. 455-460

    26.Yoji Saitoa, Takeshi Kosugeb, ”Honeycomb-textured structures on crystalline silicon surfaces for solar cells by spontaneous dry etching with chlorine trifluoride gas”

    27.Ching-Hsi Lin , Song-Yeu Tsai, Shih-Peng Hsu, Ming-Hsun Hsieh,“Investigation of Ag-bulk/glassy-phase/Si heterostructures of printed Ag contacts on crystalline Si solar cells”

    QR CODE