研究生: |
施慶濃 CHING-NUNG SHIH |
---|---|
論文名稱: |
雙變壓器全橋串聯諧振式直流/直流轉換器研製 Design and Implementation of a Two-Transformer Full-Bridge Series-Resonant DC-DC Converter |
指導教授: |
羅有綱
Yu-Kang Lo |
口試委員: |
邱煌仁
Huang-Jen Chiu 劉益華 Yi-Hua Liu 歐勝源 none |
學位類別: |
碩士 Master |
系所名稱: |
電資學院 - 電子工程系 Department of Electronic and Computer Engineering |
論文出版年: | 2008 |
畢業學年度: | 96 |
語文別: | 中文 |
論文頁數: | 67 |
中文關鍵詞: | 串聯諧振轉換器 、LLC形式串聯諧振轉換器 、雙變壓器全橋架構 、零電壓切換技術 |
外文關鍵詞: | series resonant converter, LLC-type SRC, two-transformer full-bridge topology, zero-voltage switching technique |
相關次數: | 點閱:590 下載:11 |
分享至: |
查詢本校圖書館目錄 查詢臺灣博碩士論文知識加值系統 勘誤回報 |
本論文介紹串聯諧振式轉換器(Series Resonant Converter,簡稱SRC)與LLC型式串聯諧振式轉換器(LLC-Type Series Resonant Converter,簡稱LLC SRC)的理論基礎及動作狀態分析,並分析各動作區間之等效電路,與推導串聯諧振轉換器各區間動作之數學模型。本論文同時針對全橋LLC串聯諧振式轉換器進行電路分析,並使用MATLAB數學模擬軟體完成品質因數(Q)、K因子、特性阻抗(Zo)、變壓器圈數比(NP/NS)與一次側激磁電感(Lm)之響應模擬。
本論文研製一台雙變壓器全橋LLC形式串聯諧振轉換器,此架構之優點為變壓器可均分輸出負載電流,分散變壓器體積,並易於實現電源供應器高功率密度之要求,藉由設定諧振頻率及特性阻抗,可計算出各元件之値。最後實作一台輸出規格為12V/42A之雙變壓器全橋LLC串聯諧振式轉換器,除了將實測結果和理論相互印證之外,並研擬未來研究方向。
This thesis focuses on the analysis of basic theories and operating modes of a series resonant converter (SRC) and an LLC-type SRC. The equivalent circuits and their mathematical models for each operation modes are also discussed. The main focus is on analyzing a full-bridge LLC-type SRC. MATLAB simulations are performed to observe the influences of the quality factor (Q), the K factor, the characteristics impedance (Zo), the transformer turns-ratio (Np/Ns), and the primary magnetizing inductance Lm on the frequency response of the voltage gain.
A two-transformer full-bridge LLC-type SRC prototype is implemented. The advantages of this topology are the inherent load current sharing, reduced transformer sizes, and feasible for high power density requirement. From the specified resonant frequency and characteristics impedance, the circuit components can be calculated. Lastly, a two-transformer LLC-type SRC with an output voltage of 12 V and an output current of 42 A is realized. Theoretical analyses are verified with the experimental results. Also future works for this research are included.
[1] F. C. Lee, “High-Frequency Quasi-Resonant and Multi-Resonant Converter Technologies,“ IEEE IECON, pp. 509-521, 1988.
[2] J. G. Cho, J. A. Sabate, and F. C. Lee, “Novel Full Bridge Zero-Voltage-Transition PWM DC/DC Converter for High Power Applications,” IEEE PESC, pp. 143-149, 1994.
[3] J. Feng, Y. Hu, W. Chen, and C. C. Wen, “ZVS Analysis of Asymmetrical Half-Bridge Converter,” IEEE PESC, vol. 1, pp. 243-247, 2001.
[4] J. W. Baek, J. G. Cho, D. W. Yoo, G.H. Rim, and H.G. Kim, “An Improved Zero Voltage and Zero Current Switching Full Bridge PWM Converter with Secondary Active Clamp”, IEEE PESC, pp. 948-954. 1998.
[5] C. M. Wang, “A New Family of Zero-Current-Switching (ZCS) PWM Converter,” IEEE Transactions on Industrial Electronics, vol. 52, pp. 1117-1125, 2005.
[6] A. K. S. Bhat, “Analysis and Design of a Modified Series Resonant Converter,” IEEE Transactions on Power Electronics, vol. 8, pp. 423-430, 1993.
[7] J. P. Agrawal, K. siri, and C. Q. Lee, “Determination and Minimization of Cross Regulation in Multi-Output High Order SRC,” IEEE Trans. Circuits and Systems, vol. 1, pp. 692-695. 1990.
[8] F. S. Tsai and F. C. Lee. “A Complete DC Characterization of a Constant-Frequency, Clamped-Mode, Series Resonant Converter,” IEEE PESC, pp. 987-996, 1988.
[9] M. K. Kazimierczuk and S. Wong, “Frequency-Domain Analysis of Series Resonant Converter for Continuous Conduction Mode,” IEEE Transactions on Power Electronics, vol. 7, no. 2, pp. 270-279, 1992.
[10] M. K. Kazimierczuk and D. Czarkowski, “Resonant Power Converters,” Wiley-Interscience publication, ISBN 0-471-04706-6.
[11] S. C. Wong, A. D. Brown, Y. S. Lee, and S. W. Ng, “Parasitic Losses Modeling of a Series Resonant Converter Circuit,” IEEE Circuits and Systems, vol. 2, pp. 921-924, 1997.
[12] 顏上進,「串聯諧振轉換器輕載調制策略之研究」,國立台灣科技大學電子工程系研究所博士論文,民國九十五年。
[13] 謝明琮,「適合全載範圍操作之全橋相移式串聯諧振直流/直流轉換器研製」,國立台灣科技大學電子工程系研究所碩士論文,民國九十六年。
[14] 楊馨傑,「液晶電視400瓦交/直流電源模組之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國九十六年。
[15] R. Elferich and T. Duerbaum, “A New Load Resonant Dual Output Converter,” IEEE PESC, pp. 1319-1324, 2002.
[16] R. Liu and C. Q. Lee, “Analysis and Design of LLC-type Series Resonant Converter,” IEE Proc. vol. 24, no. 24, pp. 1517-1519, 1988.
[17] K. Siri and C. Q. Lee, “Constant Switching Frequency LLC-type Series Resonant Converter,” IEEE Circuits and Systems, vol. 1, pp. 513-516, 1989.
[18] R. Liu, C. Q. Lee, and A. K. Upadhyay, “Experimental Study of the LLC-type Series Resonant Converter,“ IEEE APEC, pp. 31-37, 1990.
[19] A. K. S. Bhat, “Analysis and Design of LCL-type Series Resonant Converter,” IEEE Transactions on Industrial Electronics, vol. 41, no. 1, pp. 118-124, 1994.
[20] B. Yang, F. C. Lee, A. J. Zhang, and G. S. Huang, “LLC Resonant Converter for Front End DC/DC Conversion,” IEEE APEC, pp. 1108-1112, 2002.
[21] B. Lu, W. Liu, Y. Liang, F. C. Lee, and J. D. Van Wyk, ”Optimal Design Methodology for LLC Resonant Converter,” IEEE APEC, pp. 533–538. 2006.
[22] L. Yan, L. Wenduo, L. Bing, and D. J. Wyk, “Design of Integrated Passive Component for a 1MHz 1kW Half-Bridge LLC Resonant Converter,” IEEE IAC, pp. 2223-2228, 2005.
[23] R. Liu, L. Batarseh, and C. Q. Lee, “Comparison of Performance Characteristics between LLC-type and Conventional Parallel Resonant Converters,” Electronics Letters, vol. 24, no. 24, pp. 1510-1511, 1988.
[24] R. Cheng, Y. Yang, and Y. Jiang, ”Design of LLC Resonant Converter with Integrated Magnetic Technology,” IEEE ICEMS, pp. 1351-1355, 2005.
[25] B. Yang, “Topology Investigation for Front End DC/DC Power Conversion for Distributed Power,” PhD dissertation, 2003.
[26] S. A. Liang, “Design Optimization for LCD TV Power Supply with Resonant Technique,” IEEE PESC, pp. 702-707, 2007.