研究生: |
陳冠廷 Kuan-ting Chen |
---|---|
論文名稱: |
具功率因數修正器關閉功能之雙模式返馳式轉換器研製 Study and Implementation of a Dual-Mode Flyback Converter with Power Factor Corrector Turn-Off Feature |
指導教授: |
羅有綱
Yu-Kang Lo 邱煌仁 Huang-Jen Chiu |
口試委員: |
楊宗銘
Chung-Ming Young 王建民 Jian-Min Wang |
學位類別: |
碩士 Master |
系所名稱: |
電資學院 - 電子工程系 Department of Electronic and Computer Engineering |
論文出版年: | 2010 |
畢業學年度: | 98 |
語文別: | 中文 |
論文頁數: | 104 |
中文關鍵詞: | 功因修正器 、固定截止時間 、雙模式 、準諧振返馳式轉換器 |
外文關鍵詞: | fixed off- time control, light-load efficien |
相關次數: | 點閱:313 下載:9 |
分享至: |
查詢本校圖書館目錄 查詢臺灣博碩士論文知識加值系統 勘誤回報 |
本論文提出一組準諧振返馳式轉換器之控制電路,改善傳統準諧振返馳式轉換器操作於不連續電流導通模式下較高的重載峰值電流。所提控制器利用一組波谷切換偵測機制達到準諧振零電壓切換,降低輕載操作的切換損失;及一組固定截止時間機制,達到重載操作時限制開關的截止時間,使電流進入連續導通模式而降低導通損。本文除了對準諧振返馳式轉換器作理論分析,並以提出的雙模式控制方式實作一台輸出直流電19 V、額定輸出功率140 W之準諧振返馳式轉換器。
本文並利用雙模式操作之準諧振返馳式轉換器之優點,來實現與測試一部140W的雛型電源供應器,前級電路利用邊界導通模式功率因數修正電路,用以改善輸入功率因數。在輕載條件下將前級功率因數修正器關閉,以減少電路整體損耗、提高轉換效率。後級電路為具有雙模式操作之準諧振返馳式轉換器,140W電源供應器的整體效率可達86%。
This thesis presents a new control circuit for a quasi-resonant (QR) flyback converter to reduce the high peak current of a traditional discontinuous conduction mode (DCM) flyback converter at heavy loads. The proposed controller uses a valley-switching detector to achieve zero voltage switching. Also a fixed off-time control allows the converter to operate under continuous conduction mode (CCM) to decrease the conduction loss at heavy loads. Implement theoretical analysis and design a 140W Flyback converter by Dual-mode control method proposed in this paper.
A 140-W QR flyback converter prototype with dual-mode control is built and tested to verify the theoretical analysis. The pre-regulator is a transition-mode (TM) PFC for achieving a unity input power factor (PF). And the PFC turn-off function at light loads is fulfilled by detecting the load current to improve the light-load conversion efficiency. The post-stage circuit is a dual-mode QR flyback. The measured overall efficiency of the developed 140-W adapter can be up to 86%.
[1] K. Harada and H. Sakamoto, “Switched snubber for high frequency switching, ”in Proc. Power Electron. Spec. Conf , pp. 181-187,1990.
[2] Christophe Basso,“How to deal with leakage elements in flyback converters, ”On Semiconductor, AN1679/D.
[3] M. Bildgen, “Resonant converter topologies, ”ST Microelectronics, AN658/1194.
[4] K. Liu, R. Oruganti, and F. C. Lee, “Resonant switches topologies and characteristics,”IEEE Trans. On Power Electronics, Vol. PE-2, No.1, pp. 62-74,1987.
[5] V. Vorpe’rian,“Quasi-square-wave converters: topologies and analysis,”IEEE Trans. On Power Electronics, Vol. 3, No.2, pp. 183-191,1998.
[6] E. Ismail and A. Sebzali,“A new class of quazi-square wave resonant converters with ZCS,” IEEE . Applied Power Electronics Specialists Conf., Vol. 1 and 2, pp. 1381-1387,1997.
[7] Bor-Ren Lin, Huan-Keng Chiang, Chien-En Huang and Koa-Cheng Chen,“Analysis of an active clamp forward converter,” IEEE PEDS 2005, pp. 140-145.
[8] ST Microelectronics “Solution for designing a 400W fixed off-time controlled PFC pre-regulator with the L6562A,” application note, 2008.
[9] Data Sheet, NCP1207A, NCP1207B “PWM current-mode controller for free running quasi-resonant operation,” On Semiconductor, Nov, 2007 ,Rev. 8.
[10] ST Microelectronics, “L6561, enhanced transition mode power factor corrector,” Application Note, AN966, March. 2003.
[11] 柯祈佑,「高效能非對稱半橋轉換器之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國98年。
[12] 洪瑞鴻,「2kW功率因數修正器研製」,國立台灣科技大學電子工程系研究所碩士論文,民國94年。
[13] 黃健淳,「250W局部零電壓切換準諧振升壓型功率因數修正器之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國98年。
[14] A. I. Pressman, “Switching power supply design,” Second Edition,McGraw-Hill, 1998.
[15] 陳文富,「200瓦LED路燈電源供應器研製」,國立台灣科技大學電子工程系研究所碩士論文,民國99年。
[16] 梁適安,「交換式電源供應器之理論與實務設計」,全華科技圖書出版,民國93年10月。
[17] 原田耕介,新型柔性切換式電源技術入門,第一版,全華科技圖書股份有限公司,1992年。
[18] 簡銘德,「700W備援式伺服系統電源供應器之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國98年。
[19] 顏至良,「主僕式準諧振返馳式轉換器之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國97年。
[20] Nicolas Cyr “A 75W TV power supply operating in quasi-square wave resonant mode using the NCP1207 controller,” On Semiconductor,AND8145/D.
[21] 陳宏安,「戶外交接箱饋電系統之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國98年。
[22] Petr Lidak,“Implementing NCP1207 in QR 24W AC-DC converter with synchronous rectifier,”On Semiconductor, AND8127/D.
[23] 林彥廷,「雙模式功率因數修正器之研製」,國立台灣科技大學電子工程系研究所碩士論文,民國99年。
[24] 謝沐田,高低頻變壓器設計,全華科技圖書股份有限公司,2005年11月。
[25] TDK Ferrite Cores for Power Supply and EMI/RFI Filter, 2007.
[26] 鄭玉南,「返馳式轉換器緩振電路研究」,國立台灣科技大學電子工程系研究所碩士論文,民國92年。