二氧化銥奈米桿在還原後之表面現象分析及氣體感測性質之研究

簡易檢索 / 詳目顯示

回結果列表

研究生：	裴紹凱 Shao-kai Pei
論文名稱：	二氧化銥奈米桿在還原後之表面現象分析及氣體感測性質之研究 Effect of reduction iridium dioxide nanostructure for surface analysis and gas sensing properties
指導教授：	劉進興 Chin-Hsin J. Liu
口試委員:	蔡大翔 Dah-Shyang Tsai 施正雄 Shih, Jeng-Shong 江志強 Jyh-Chiang Jiang
學位類別：	碩士 Master
系所名稱：	工程學院 - 化學工程系 Department of Chemical Engineering
論文出版年：	2007
畢業學年度：	95
語文別：	中文
論文頁數：	113
中文關鍵詞：	二氧化銥、QCM 、氣體感測
外文關鍵詞：	IrO2, QCM, Gas sensor
相關次數：	點閱：230 下載：1
分享至:	分享至facebook 分享至twitter

查詢本校圖書館目錄查詢臺灣博碩士論文知識加值系統勘誤回報

本論文主要利用化學氣相沉積(MOCVD)方式，在鍍於石英晶片上之金電極表面沉積二氧化銥，以此製作QCM質量式感測器，針對酸類及胺類氣體進行感測，發現有不錯的感測靈敏度，其偵測濃度可達數個ppm。
當我們將IrO2置於高真空環境下，以不同還原溫度(450 oC~600 oC)及還原時間(30分鐘~90分鐘)，可使IrO2 部份去氧還原，利用XRD、XPS、拉曼光譜、SEM進行還原前後的表面分析。並結合模擬計算探討其吸附與脫附機制。
由XPS分析來看，二氧化銥還原前表面組成為IrO2 / IrO3 / Ir(OH)x，感測1000ppm丙酸所得訊號為160Hz、可逆性73%；在450 oC進行還原，表面組成不變，丙酸訊號仍為160Hz，但可逆性為88%；還原溫度提高至550 oC，則表面還原成Ir/IrO2，丙酸訊號提高為270Hz，可逆性達98%。即其靈敏度比還原高，且可逆性更佳。
當還原溫度再提高至600 oC時，丙酸訊號提高至320Hz，但可逆性降低至32%。為了改善可逆程度，我們預先在金電極上濺鍍ㄧ層Ti薄膜，並在相同的熱還原處裡條件下將IrO2脫氧，發現可逆性可大幅提升至80%。

Nanostructured IrO2 crystals are grown on a gold-coated quartz substrate by metal organic chemical vapor deposition (MOCVD). The resultant quartz crystal microbalance (QCM) sensor shows a good gas sensitivity towards carboxylic acid and amine vapors at the ppm level.
When the oxide is heated at 450oC~600oC in high vacuum, the IrO2 is partially reduced by thermal decomposition. The composition and the morphology of the sample surface before and after reduction are investigated by X-ray diffraction (XRD), X-ray photoelectron spectroscopy (XPS), Raman spectroscopy, and scanning electron microscopy (SEM). Molecular simulation is also used to explain the mechanism of adsorption and desorption.
From XPS analysis, we find that the sample surface composition is IrO2/IrO3/Ir(OH)x before reduction. Upon exposure to 1000 ppm of propanic acid vapors, the QCM frequency shift is found to be 160 Hz with 73% reversibility when desorbed; After a reduction at 450oC, the surface composition and the QCM frequency shift remain the same, while the reversibility becomes 88%; When the reduction is carried out at 550 oC, the surface is reduced to become Ir/IrO2, and the Ir/IrO2 sensor shows a higher gas sensitivity (~270 Hz) and better reversibility (~98%) as compared to the IrO2/IrO3/Ir(OH)x sensor.
When reduction temperature is further increased to 600oC, the sensor shows an even higher sensitivity (~320Hz) but lower reversibility (~32%). However, if a thin Ti layer onto the Au electrode before growing the IrO2 crystals, followed by the 600oC reduction treatment, then the reversibility of the sensor can be improved to about 80%.

中文摘要...I
英文摘要..III
致謝.....	V
目錄.....	VII
圖目錄...	XI
表目錄...	XVI
第一章  緒論......	1
1 氣體感測器簡介.......	1
2 半導體金屬氧化物感測材料......	2
3 氣體感測器的種類.....	2
4 研究動機.............4
第二章 文獻回顧.........6
1 IrO2晶體之結構.......	6
2 IrO2晶體導電性.......	7
3 IrO2晶體成長.........	8
4 IrO2之場發射(Field Emission)特性.......	10
5 IrO2對氣體感測之應用..........	11
6 石英晶體微量天平（Quartz Crystal Microbalance)..	12
6.1石英震盪器之壓電性（Piezoelectricity）.......	12
6.2 QCM偵測之理論模式建立.....	14
7 金屬對金屬氧化物性質的影響....	16
8 金屬氧化物的還原脫氧...........18
8.1 脫氧位置探討..........................................18
8.2 IrO2脫氧還原之反應機制....................................20
8.3分子吸附於金屬氧化物表面之反應機制......................... 22
9 拉曼光譜法介紹......................................... 22
9.1 拉曼光譜法與紅外線光譜法的差異................................ 22
9.2 脫氧還原前/後的拉曼光譜....................................... 23
第三章 實驗方法及步驟.......25
1實驗藥品.......25
2 儀器設備......25
3 實驗流程......29
4 石英震盪晶體處理................................................................... 30
5 以MOCVD法製備IrO2 / D-IrO2薄膜步驟.......................... 31
6 結構分析與性質量測儀器........................................... 33
7 QCM(Quartz Crystal Membrane)裝置....................................... 35
8 參數定義........................................................... 37
第四章 結果與討論.....39
0 實驗目的...............................................39
1  X-ray分析..........................................................39
1.1還原溫度之影響.............................................. 39
1.2還原時間之影響................................................... 43
2  SEM分析....................................................... 46
2.1 還原溫度之影響.......................................... 46
2.2 還原時間之影響............................................ 46
3  拉曼光譜分析.................................................49
3.1還原溫度之影響............................................ 49
3.2還原時間之影響.............................................54
4  XPS分析................................................................59
4.1  還原溫度之影響............................................... 59
4.2  還原時間之影響............................................... 65
4.2  XPS縱深分析.....................................................69
5  氣體感測........................................................71
5.1  IrO2對丙酸之氣體感測.......................................72
5.1.1  IrO2還原時間的影響.................................. 72
5.1.2  IrO2還原溫度的影響..................................74
5.1.3  IrO2還原溫度與還原時間的相互關係....................76
5.1.4  IrO2/Ti、d-IrO2/Ti 電極製備...................................78
5.1.4.1  SEM表面型態分析...................................... 78
5.1.4.2  X-ray分析......................................... 81
5.1.4.3  Raman光譜分析........................................... 82
5.1.4.4  XPS分析........................................ 83
5.1.4.5  IrO2/Au、IrO2/Ti/Au在還原後之氣體感測....87
5.1.5  IrO2還原前後丙酸感測再現性................................89
5.1.6  濃度極限..............................................91
5.1.7  以模擬計算探討丙酸分子在脫氧晶格內的吸附行為......93
5.2  IrO2對己胺之氣體感測................................95
        4.5.2.1  IrO2還原時間的影響.............................95
        4.5.2.2  IrO2還原溫度的影響................................97
        4.5.2.3  IrO2/Au、IrO2/Ti/Au在還原後之氣體感測............99
第五章 結 論............................................... 101
第六章 參考文獻..................................................... 104

                                

1. 施正雄, 科學發展月刊, 27 (1999) 1184

2. Y. H. Ju, C. J. Liu and J. C. Hsieh, J. Chin. Inst. Chem. Engrs., 29
(1998) 415

3. C. J. Liu, S.Y. Wang, J. C. Hsieh and Y. H. Ju, Sensors and Actuators, B65
(2000) 371

4. C. J. Liu , C. H. Peng, Y. H. Ju and J. C. Hsieh, Sensors & Actuators, B52
(1998) 264

5. C. J. Liu, W. C. Hou and Y. H. Ju, J. Chin. Inst. Chem. Engrs., 31 (2000)
237

6. C. J. Liu, J. C. Hsieh and Y. H. Ju, J. Vac. Sci. Technol. A14 (1996) 753

7. Y. H. Ju, J. C. Hsieh and C. J. Liu, Thin Solid Films, 342 (1999) 238

8. J. C. Hsieh , C. J. Liu and Y. H. Ju, Thin Solid Films, 322 (1997) 98

9. G. G. Guilbault, and J. M. Jordan, CRC Critical Review in Analytical
Chemistry, 19 (1988) 1

10. J. W. Grate, S. J. Martin and R. M. White, Anal. Chem., 65 (1993)
90A

11. 蔡嬪嬪、曾明漢, 材料與社會, 68 (1992) 50

12. G. Z. Sauerbrey, Phys., 155 (1959) 206

13. J. Y. Jo, J. G. Yoon, J. K. Lee, J. M. Koo, J. Y. Won, S. P. Kim, and
T. W. Noh, Integr. Ferroelectr., 67 (2004) 143

14. M. F. Smiechowski, V. F. Lvovich, Sensors and Actuators B, 96 (2003) 261

15. S. A. M. Marzouk, Anal. Chem., 75 (2003) 1258

16. A. N. Bezbraruah and T. C. Zhang, Anal. Chem., 74 (2002) 5726

17. H. Beyenal, C. C. Davis, Z. Lewandowski, Sensors and Actuators, 97 (2004)
202

18. T.W. Chao, C.J. Liu, A.H. Hsieh, H.M. Chang, Y.S. Huang, D.S. Tsai,
Sensors and Actuators B (2006 in press)

19. 謝志松, “氧化釕化學氣相沉積及場發射性質”,國立台灣科技大學化學工程系碩士
論文 (2004)

20. 梁雅閔, “化學氣相沉積氧化銥奈米桿氧化銥薄膜之製備與結構分析”國立台灣科技
大學化學工程系碩士論文 (2003)

21. A. Bolzan, C. Fong, B. J.Kennedy, C. J. Howard, Acta Cryst., B53 (1997) 373

22. L. F. Mattheiss, Phys. Rev., B13 (1976) 2433

23. Hackwood, S., L. M. Schiavone, W. C. Dautremont-Smith and G. Beui, J.
Electrochem. Soc., 128 (1981) 2569

24. L. F. Mattheiss, Phys. Rev. B13 (1976) 2433

25. W. D. Ryden and A. W. Lawson, Phys. Rev. B1 (1984) 1813

26. L. F. Mattheiss, Phys. Rev. B13 (1976) 2433

27. Hackwood, S., L. M. Schiavone, W. C. Dautremont-Smith and G.
Beui, J. Electrochem. Soc., 128 (1981) 2569

28. Weudt , and H. M. Kuhne, Conference Record of Twentieth IEEE
photovoltaic Specialists, 2 (1988) 1656

29. Swette, I., N. Kackley and S. A. McCatty, J. of Power Source., 36
(1991) 323

30. Hamnett, P. S. Newcastle and R. D. Wingate, J. of Appl.
Electrochemistry., 24 (1991) 982

31. J. E. Oxley , Proceedings of the 34th Internationol Power Sources
Symposium, (1990) 346

32. M. Lambrechts and W. Sansen, Sensors and Actuators, 13 (1988) 287

33. W. OlThuis, J. C. Van KerKhof and P. Bergveld, Sensors and
Actuators, B4 (1991) 151

34. J. A. Mihell, J. K. Atkinson, Sensors and Actuators, B48 (1998) 505

35. M. Robert, Ianniello, M. A. A. Yacynych, Analytical Chimica Acta, 146
(1983) 249

36. F. Matthew, Smiechowski, F. V. Lvovich, Sensors and Actuators,
B96 (2003) 261

37. N. Dario, O. Alberto, and M. M. Claudio, Sensors and Actuators B,
18-19 (1994) 566

38. A. Karthigeyan, R. P. Gupta, K. Scharnagl, Sensors and Actuators,
B85 (2002) 145

39. I. Toro, W. David, Chipman, T. Taro, T. Katuso, Sensors and Actuators,
B76 (2001) 265

40. A. Salomonsson, S. Roy, C. Aulin, Sensors and Actuators, B107 (2005) 831

41. R. S. Chen, Y. S. Huang, Y. M Liang, D. S. Tsai, Y. Chi and J. Kai,
Journal of Materials chemistry, 13 (2003) 2525

42. R. S. Chen,Y. S. Huang, D. S. Tsai, S. Chattopadhyay, C. T. Wu,
Z. H. Lan and K. H. Chen, Chem. Mater., 16 (2004) 2457

43. R. S. Chen and Y. S. Huang, Y. M. Liang, C. S. Hsieh, D. S. Tsai,
K. K. Tiong, Applied Physics Letters, 84 (2004) 1552

44. T. R. Ling, C. M. Tsai, Sensors and Actuators B (2006 in press)

45. T. W. Chao, C. J. Liu, A. H. Hsieh, H. M. Chang, Y.S. Huang,
D.S. Tsai, Sensors and Actuators B (2006 in press)

46. P. J. Curie, C. R. Acad. Sci., 91 (1880) 294

47. M. D. Ward, D. A. Buttry, Science, 249 (1990) 1000

48. J. W. Grate , S. J. Martin and R. M. White, Anal. Chem., 65 (1993)
940A

49. T. R. Ling, C. M. Tsai, Sensors and Actuators B (2006 in press)

50. C. Lu, A. W. Czanderna, Elsevier Science, New York, (1984)

51. R. S. Niranjan, I. S. Mulla, Material and Engineering B103 (2003)
103

52. Z. P. Liu, J. J. Stephen, and A. K. David, Physical Review Letters,
93 (2004) 15

53. S. Shukla, L. Ludwig C. Parrish, S. Seal, Sensors and Actuators B
104 (2005) 223

54. T. R. Ling, C. M. Tsai, Sensors and Actuators B (2006 in press)

55. A. Tiburico-Silver, Solar Energy Materials and Solar Cells 91 (2007)
207

56. A. P. Roth, J. B. Webb, D. F. Williams, Phys. Rev. B 25 (1982) 7836

57. B. Joseph, Bull. Mater. Sci. 22 (1999) 921

58. S. G. Wang , X. D. Wen , D. B. Cao , Y. W. Li ,J. Wang , H. Jiao,
Surface Science 577 (2005) 69

59. A. Tiburcio-Silver, J. C. Joubert, M. Labeau, Thin Solid Films 197
(1991) 195

60. R. L. Kurtz, R. Stockbaur, T. E. Madey, Surface Science 218 (1989)
178

61. P. Ciureanu, Thin Film Resistive Sensors (1992) 451

65. Y. S. Huang, S. S. Lin, C.R. Huang, M. C. Lee, T. E. Dann,
F. Z. Chien, Solid State Communications, 70 (1989) 517

63. G. H. Azarbayejani, Appl. Phys. Lett. 47 (1985) 12.

64. Z. Jiao, M. Wu, Z. Qin, M. Lu and J. Gu, Sensors, 3 (2003) 285

66. 胡興中，觸媒原理與應用，高立圖書有限公司 (1996).

67. J. E. Lennard-Jones, Trans. Faraday Soc., 28 (1932) 333.

68. S. J. Gentry and T. A. Jones, Sensors and Actuators, 10 (1986) 141.

69. 林鴻明、曾世杰，工業材料，157 (2000) 163

70. C. Xu, J. Tamaki, N. Miura and N. Yamazoe, Sensors and Actuators
B (1991) 147

71. R. S. Niranjan, I. S. Mulla*, Material and Engineering B103 (2003)
103

72. Y. S. Huang, S. S. Lin, C.R. Huang, M. C. Lee, T. E. Dann,
F. Z. Chien, Solid State Communications, 70 (1989) 517

72. M. Pourbaix, Pergamon Press, Oxford, England (1996)

73. C. Mousty, G. Foti, Ch. Comninellis, V. Reid, Electrochimica Acta
45 (1999) 451

74. R. S. Chen, H. M. Chang, Y. S. Huang, D. S. Tsai, S. Chattopadhyay,
K. H. Chen, J. Cryst. Growth, 271 (2004) 105

75. Y. H. Song, Y. L. Chen, Y. Chi, S. S. Liu, W. L. Ching, J. J. Kai,
R. S. Chen, Y. S. Huang, and J. C. Arthur, Chem. Vap. Deposition. 9
(2003) 162

76. 單啟齊,“催化有機小分子氧化反應之鉑-銥-氧化銥薄壁電化學
觸媒”,國立台灣科技大學化學工程系碩士論文 (2006)

77. J. Augustynski, M. Koudelka and J. Sanchez, J. Electroanal. Chem.,
160 (1984) 233

78. R. S Chen, H. M. Chang, Y. S. Huang, D. S. Tsai, S. Chattopadhyay,
K. H. Chen, J. Cryst. Growth., 271 (2004) 105

79. 謝安和,“二氧化銥之氣體感測性質以及濺鍍金屬之影響,
國立台灣科技大學化學工程系碩士論文 (2006)

80. T. W. Chao, C. J. Liu, A. H. Hsieh, H. M. Chang, Y. S. Huang,
D. S. Tsai, Sensors and Actuators B (2006 in press)

81. A. J. Terezo and E. C. Pereira, Electrochim. Acta. 44 (1999) 4507.

82. M. Boudart, Adv. Catal, 19 (1969) 153

83. R. S. Chen, Y. S. Huang, Y. M. Liang, D. S. Tsai, Y. Chi and J. J. Kai,
J. Mater. Chem., 13 (2003) 2525

84. Y. Y. Hou, J. M. Hu, L. Liu, J. Q. Zhang, and C. N. Cao, Electrochimica
Acta., 51 (2006) 6258

85. L. Quattara, T. Diaco, I. Duo, M. Panizza, G. Foti and Ch. Cominellis,
J. Electrochem. Soc. 150 (2003) D41

86. G.. Foti, C. Mousty, V. Reid, Ch. Comninellis, Electrochim Acta.
44 (1998) 813

87. F. Beck, H.J. Schulz, J. Electroanal. Chem. 229 (1987) 339.

88. E. Lodowicks, F. Beck, Chem. Eng. Technol. 17 (1984) 338.

89. D. T. Shieh, B. J. Hwang, J. Electro. Chem. Soc. 142 (1995) 816

90. A. R. de Andrade, P. M. Donate, P. P. D. Alves, C. H. V. Fedellis,
J. F. C. Boodts, J. Electrochem. Soc. 145 (1998) 3839

91. J. W. Kim, S. M. Park, J. Electrochem. Soc. 146 (1999) 1075

92. G. Foti, D.Gandini, Ch. Comninellis, Curr. Top. Electrochem.
5 (1997) 71

93. R. S. Chen, Y. S. Huang, Y. M. Liang, D. S. Tsai, K. K. Tiong,
Journal of Alloys and Compounds 383 (2004) 273

94. W. G. Julian, S.W. Hyun and L. H. Evor, Sensors and
Actuators B, 70 (2000) 19

95. S. lijima, “Helica microtubules of graphic carbon”, Nature 354
(1991) 56

簡易檢索 / 詳目顯示

相關論文